The nontrivial effects of annealing on superconducting properties of Nb single crystals

Abstract

The effect of annealing on the superconducting properties of niobium single crystals cut from the same master boule was studied by local and global magnetic measurements, as well as scanning tunneling microscopy (STM). The formation of large hydride precipitates was observed in unannealed samples. The variation in structural and magnetic properties was studied after annealing under high vacuum at 800 C, 1400 C, and near the melting point of niobium (2477 C) for a few seconds. The initial samples had a high hydrogen content. Polarized optics and magneto-optical studies show that the formation of large niobium hydride precipitates is suppressed already by 800 C annealing. However, the overall superconducting properties in the annealed samples did not improve after annealing, and in fact, worsened. The superconducting transition temperature decreased, the upper critical field increased, and the pinning strength increased. Parallel studies were conducted using STM, where the sample was annealed initially at 400 C, measured, annealed again at 1700 C, and measured again. These studies revealed a ``dirty'' superconducting gap with a significant spatial variation of tunneling conductance after annealing at 400 C. The clean gap was recovered after annealing at 1700 C. It is likely that these results are due to oxygen redistribution near the surface, which is always covered by oxide layers in as-grown crystals. Overall, the results indicate that vacuum annealing at least up to 1400 C, while expected to remove a large amount of hydrogen, introduces additional nanosized defects, perhaps hydride precipitates, that act as efficient pair-breaking and pinning centers.